Dodge Grand Caravan Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Dodge Grand Caravan
The Dodge Caravan is a passenger minivan manufactured by Chrysler and marketed under the Dodge brand. Introduced for model year 1984 and now in its fifth generation, the Caravan has been offered in short-wheelbase (1984-2007) and long-wheelbase (1987-present) variants, the latter as the Grand Caravan. The Grand Caravan is the sibling vehicle of the Chrysler Town & Country. It is manufactured with both manual and automatic transmission styles. The 2014 Dodge Grand Caravan is built in Windsor Assembly Plant in Windsor, Ontario, Canada.
Dodge Grand Caravan FAQ's
How do I change the oil in my Dodge Grand Caravan?
First, drain the old oil by removing the drain plug and allowing the oil to drain into a pan. Then, replace the drain plug and remove the oil filter. Install a new oil filter by lubricating the gasket and screwing it onto the engine. Finally, add new oil to the engine through the oil fill cap.
How do I check the brake fluid level on my Dodge Grand Caravan?
Locate the brake fluid reservoir under the hood and check the fluid level by looking at the markings on the side of the reservoir. If the fluid level is low, add brake fluid until it reaches the recommended level. Be sure to use the correct type of brake fluid for your vehicle.
How do I check the transmission fluid level in my Dodge Grand Caravan?
Start the engine and allow it to reach normal operating temperature. Shift the transmission through each gear and then back to park. Locate the transmission dipstick, remove it, and wipe it clean. Reinsert the dipstick and remove it again to check the fluid level. Add fluid if necessary.
How do I replace the air filter in my Dodge Grand Caravan?
Locate the air filter housing under the hood and remove the clips or screws securing the cover. Lift the cover off and remove the old air filter. Install the new air filter, making sure the rubber seal is seated properly. Replace the cover and secure it with the clips or screws.
How do I replace the battery on my Dodge Grand Caravan?
First, remove the negative cable from the battery terminal, then remove the positive cable. Next, remove the battery hold-down clamp and lift the battery out of the tray. When installing the new battery, connect the positive cable first, then the negative cable, and secure the hold-down clamp.
How do I replace the brake pads on my Dodge Grand Caravan?
Remove the wheel and locate the brake caliper. Use a C-clamp to compress the caliper piston, then remove the caliper bolts and lift the caliper off the rotor. Remove the old brake pads and install the new pads. Reinstall the caliper and tighten the bolts.
How do I replace the cabin air filter on my Dodge Grand Caravan?
Locate the cabin air filter housing, which is typically under the dashboard on the passenger side. Remove the cover and take out the old filter. Install the new filter, making sure it is facing the correct direction. Replace the cover.
How do I replace the fuel filter on my Dodge Grand Caravan?
Locate the fuel filter under the vehicle and use a wrench to loosen the fuel lines. Remove the fuel filter and install the new filter, making sure the flow arrows are pointing in the correct direction. Tighten the fuel lines and start the engine to check for any leaks.
How do I replace the headlights on my Dodge Grand Caravan?
To replace the headlights on a Dodge Grand Caravan, locate the headlight assembly under the hood and remove the retaining clips or screws. Pull the assembly out of the vehicle and disconnect the wiring harness. Install the new headlight assembly by connecting the wiring harness and securing it with the retaining clips or screws.
How do I replace the serpentine belt on my Dodge Grand Caravan?
Locate the belt routing diagram under the hood and use it as a guide to remove the old belt. Release the tension on the belt by using a wrench to turn the tensioner pulley. Remove the old belt and install the new belt, following the diagram. Use the wrench to release the tension on the tensioner pulley and ensure the belt is properly seated.
What is causing my Dodge Grand Caravan to make a grinding noise when I brake?
A grinding noise when braking in a Dodge Grand Caravan is typically caused by worn brake pads or rotors. The brake pads press against the rotors to slow the vehicle, and if either of these components are worn, they can produce a grinding noise.
What is causing my Dodge Grand Caravan to overheat?
The most common causes of overheating in a Dodge Grand Caravan are a malfunctioning thermostat, a leaking radiator, or a faulty water pump. The thermostat regulates the engine's temperature, the radiator cools the engine's coolant, and the water pump circulates the coolant through the engine. If any of these components are not functioning properly, the engine can overheat.
What is causing my Dodge Grand Caravan's engine to misfire?
A misfiring engine in a Dodge Grand Caravan can be caused by several factors, including a faulty spark plug or ignition coil, a clogged fuel injector, or a vacuum leak. Check the spark plugs and ignition coils for wear or damage, inspect the fuel injectors for blockages, and check for any vacuum leaks in the engine.
What is causing my Dodge Grand Caravan's steering wheel to vibrate?
A vibrating steering wheel in a Dodge Grand Caravan can be caused by several factors, including worn or unbalanced tires, a bent wheel, or worn suspension components. Check the tires for wear or damage, balance the tires if necessary, and inspect the suspension components for wear.
Why won't my Dodge Grand Caravan start?
There are several reasons why a Dodge Grand Caravan may not start, including a dead battery, a faulty starter, a bad ignition switch, or a clogged fuel filter. Check the battery connections, listen for a clicking noise when turning the key, and inspect the fuel filter for blockages.
Dodge Grand Caravan Manuals Index
Dodge Grand Caravan on Amazon
Dodge Grand Caravan Workshop Manual
-
- Dodge Grand Caravan 1994 Workshop Manual V6 201 3.3L
- (9,801 Pages)
- (Free)
-
- Dodge Grand Caravan 1996 Workshop Manual 2.4L DOHC
- (13,587 Pages)
- (Free)
-
- Dodge Grand Caravan 1997 Workshop Manual 3.8L
- (12,869 Pages)
- (Free)
-
- Dodge Grand Caravan 1997 Workshop Manual AWD V6 3.8L
- (12,901 Pages)
- (Free)
-
- Dodge Grand Caravan 1997 Workshop Manual FWD 2.4L
- (12,691 Pages)
- (Free)
-
- Dodge Grand Caravan 1997 Workshop Manual FWD V6 3.0L SOHC
- (12,847 Pages)
- (Free)
-
- Dodge Grand Caravan 1997 Workshop Manual FWD V6 3.8L
- (12,869 Pages)
- (Free)
-
- Dodge Grand Caravan 1998 Workshop Manual 3.3L
- (11,425 Pages)
- (Free)
-
- Dodge Grand Caravan 1999 Workshop Manual 3.3L VIN R
- (9,203 Pages)
- (Free)
-
- Dodge Grand Caravan 1999 Worskhop Manual 3.0L
- (9,063 Pages)
- (Free)
-
- Dodge Grand Caravan 2001 Workshop Manual 3.8L
- (11,507 Pages)
- (Free)
-
- Dodge Grand Caravan 2002 Workshop Manual
- (4,426 Pages)
- (Free)
-
- Dodge Grand Caravan 2007 Workshop Manual
- (5,505 Pages)
- (Free)
Dodge Grand Caravan Owners Manual
-
- 2013 Dodge Grand Caravan Owners Manual
- (683 Pages)
- (Free)
-
- 2014 Dodge Grand Caravan Owners Manual
- (682 Pages)
- (Free)
-
- Dodge Grand Caravan 2004 Owners Manual
- (397 Pages)
- (Free)
-
- Dodge Grand Caravan 2005 Owners Manual
- (480 Pages)
- (Free)
-
- Dodge Grand Caravan 2006 Owners Manual
- (504 Pages)
- (Free)
-
- Dodge Grand Caravan 2007 Owners Manual
- (520 Pages)
- (Free)
-
- Dodge Grand Caravan 2010 Owners Manual
- (530 Pages)
- (Free)
-
- Dodge Grand Caravan 2011 Owners Manual
- (562 Pages)
- (Free)
Dodge Grand Caravan Misc Document
- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
