Mazda Demio Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Mazda Demio
The Mazda Demio is a supermini manufactured and marketed globally by Mazda since 1996, currently in its fourth generation. The Demio was redesigned in 2002 on the DY platform. The Demio name continued in Japan, while the rest of the world dropped 121 and other names in favor of Mazda 2. All Demios come with ABS and EBD, and stability control is optional. In Europe, trim levels were S, TS and TS2. It is manufactured with both, diesel and petrol engines and is available with either manual or automatic transmission style.Mazda Demio FAQ's
How do I change the cabin air filter in my Mazda Demio?
To change the cabin air filter in your Mazda Demio, locate the filter housing, which is usually behind the glove compartment or under the dashboard. Open the housing by releasing the clips or removing screws. Take out the old filter, paying attention to its orientation. Clean any debris or dust from the housing, and then insert the new filter in the same orientation. Close the housing and ensure it is securely fastened.
How do I change the oil in my Mazda Demio?
To change the oil in your Mazda Demio, start by locating the oil drain plug underneath the vehicle. Use a wrench to loosen and remove the drain plug, allowing the old oil to drain into a pan. Once the oil has fully drained, replace the drain plug and remove the oil filter. Install a new oil filter, and then refill the engine with the recommended amount and type of oil.
How do I check the brake fluid in my Mazda Demio?
To check the brake fluid in your Mazda Demio, locate the brake fluid reservoir, typically located near the firewall on the driver's side of the engine bay. Wipe the reservoir cap clean, then remove it. Check the fluid level, which should be between the minimum and maximum marks on the reservoir. If the fluid level is low, add the recommended brake fluid to bring it within the proper range. Be cautious not to spill brake fluid on any painted surfaces, as it can cause damage.
How do I check the tire pressure in my Mazda Demio?
To check the tire pressure in your Mazda Demio, you will need a tire pressure gauge. Start by removing the valve cap from each tire. Press the gauge firmly onto the valve stem and read the pressure displayed on the gauge. Compare the reading to the recommended tire pressure listed in the owner's manual or on the sticker inside the driver's door jamb. If the pressure is too low, add air until the desired pressure is reached. If it is too high, release some air using the valve stem.
How do I check the transmission fluid in my Mazda Demio?
To check the transmission fluid in your Mazda Demio, park the vehicle on level ground and ensure the engine is warm. Locate the transmission dipstick, typically labeled with a bright color. Remove the dipstick, wipe it clean, and reinsert it fully. Remove the dipstick again and check the fluid level. The fluid should be within the designated range on the dipstick. If it is low, add the recommended transmission fluid through the dipstick tube.
How do I perform a wheel alignment on my Mazda Demio?
Performing a wheel alignment on your Mazda Demio is best done by a professional at a reputable automotive service center. They have the necessary equipment and expertise to accurately align the wheels to the manufacturer's specifications. Wheel alignment involves adjusting the angles of the wheels to ensure proper vehicle handling, tire wear, and overall stability. It is recommended to have the wheel alignment checked periodically or if you notice signs of uneven tire wear or steering issues.
How do I replace a battery in my Mazda Demio?
To replace the battery in your Mazda Demio, first, ensure the vehicle is turned off and the engine is cool. Locate the battery, typically found in the engine bay. Disconnect the negative (black) terminal first, followed by the positive (red) terminal. Remove any clamps or brackets holding the battery in place, then lift it out carefully. Place the new battery in the same position, ensuring it is secure. Connect the positive terminal first, followed by the negative terminal.
How do I replace a headlight bulb in my Mazda Demio?
To replace a headlight bulb in your Mazda Demio, first, open the hood and locate the back of the headlight assembly. Carefully disconnect the electrical connector from the back of the bulb, then twist and remove the bulb socket counterclockwise. Pull out the old bulb and insert the new one, making sure not to touch the glass surface. Reattach the bulb socket by twisting it clockwise, and then reconnect the electrical connector.
How do I replace a spark plug in my Mazda Demio?
To replace a spark plug in your Mazda Demio, start by locating the spark plug wires or ignition coil pack. Disconnect the wire or coil pack from the spark plug, then use a spark plug socket and ratchet to remove the old spark plug. Check the gap on the new spark plug, adjust if necessary, and then thread it into the spark plug hole by hand. Finally, use the spark plug socket and ratchet to tighten the spark plug until snug.
How do I replace the brake pads in my Mazda Demio?
To replace the brake pads in your Mazda Demio, start by loosening the lug nuts on the wheel where you plan to replace the pads. Lift the vehicle using a jack and secure it on jack stands. Remove the lug nuts and wheel, then locate the brake caliper. Use a socket or wrench to remove the caliper bolts and carefully remove the caliper. Slide out the old brake pads, and then install the new ones. Reassemble the caliper, wheel, and lug nuts, ensuring everything is tightened properly.
How do I replace the wiper blades on my Mazda Demio?
To replace the wiper blades on your Mazda Demio, lift the wiper arm away from the windshield and locate the release tab or button on the wiper blade assembly. Press or slide the tab/button to release the old blade from the wiper arm. Align the new wiper blade with the arm, ensuring the hook or clip is securely attached. Gently lower the wiper arm back onto the windshield, and repeat the process for the other wiper blade.
How do I reset the maintenance light in my Mazda Demio?
To reset the maintenance light in your Mazda Demio, turn the ignition switch to the "On" position without starting the engine. Press and hold the trip meter reset button, then turn the ignition switch to the "Off" position. While still holding the reset button, turn the ignition switch back to the "On" position. Continue holding the reset button until the maintenance light turns off, indicating that the reset is complete.
How do I troubleshoot an electrical issue in my Mazda Demio?
When troubleshooting an electrical issue in your Mazda Demio, start by checking the fuses related to the problematic circuit. Use the owner's manual to locate the fuse box and identify the correct fuse. If the fuse appears to be blown, replace it with a new one of the same rating. If the issue persists, it is recommended to consult a professional or refer to the Mazda Demio automotive repair manual for further guidance on diagnosing and resolving electrical problems.
How often should I change the air filter in my Mazda Demio?
It is recommended to change the air filter in your Mazda Demio every 15,000 to 30,000 miles or as indicated in the owner's manual. However, the frequency may vary depending on driving conditions and air quality in your area. Regularly inspect the air filter and replace it if it appears dirty or clogged. A clean air filter ensures optimal engine performance and fuel efficiency.
What type of coolant should I use in my Mazda Demio?
In your Mazda Demio, it is recommended to use a coolant that meets the specifications outlined in the owner's manual. Typically, Mazda recommends using a long-life ethylene glycol-based coolant, mixed with an equal amount of distilled water. Make sure to check the coolant level regularly and top it up if necessary. If you are unsure, consult the owner's manual or reach out to a Mazda dealership for further guidance.
Mazda Demio on Amazon
Mazda Demio Owners Manual
-
- Mazda Demio Owners Manual Czech
- (106 Pages)
- (Free)
Mazda Demio Misc Document
-
- Mazda Demio 2003 Misc Documents Brochure
- (28 Pages)
- (Free)
Related Models
