Mercedes CLK 55 AMG Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Mercedes CLK 55 AMG
Mercedes-AMG GmbH, commonly known as AMG, is the high performance division of Mercedes-Benz. AMG models typically have more aggressive looks, a higher level of performance, better handling, better stability and more extensive use of carbon fiber than their regular Mercedes counterparts. AMG models are typically the most expensive and highest-performance of each Mercedes-Benz class. AMG variants are usually badged with two numerals, as opposed to regular Mercedes-Benz vehicles which have three. The CLK AMG is powered by a hand-assembled 5.4-liter V8 engine. The five-speed automatic transmission is adapted from the gearbox used in the V-12 S-class models, because that gearbox can take the torque. It was produced from 2002 until 2009.Mercedes CLK 55 AMG FAQ's
How do I bleed the brakes in my Mercedes CLK 55 AMG?
To bleed the brakes in your Mercedes CLK 55 AMG, you will need a helper and a brake bleeding tool. Start with the wheel furthest from the master cylinder (usually the rear passenger side) and have your helper pump the brake pedal several times then hold it down. Open the bleeder valve slightly, allowing the old brake fluid and air bubbles to escape. Close the valve and repeat the process until clean fluid flows without any air bubbles. Proceed to each wheel in the correct sequence, ending with the one closest to the master cylinder.
How do I change the brake pads in my Mercedes CLK 55 AMG?
To change the brake pads in your Mercedes CLK 55 AMG, start by safely lifting the vehicle and removing the wheels. Locate the brake caliper and remove the retaining bolts. Slide the caliper off the rotor and compress the caliper piston using a suitable tool. Remove the old brake pads and install the new ones, ensuring they are properly aligned. Reinstall the caliper, tighten the retaining bolts, and repeat the process for the other wheels.
How do I change the oil in my Mercedes CLK 55 AMG?
To change the oil in your Mercedes CLK 55 AMG, you will need to locate the oil drain plug underneath the engine and remove it using a wrench. Once the oil has drained completely, replace the drain plug and then remove the oil filter using an oil filter wrench. Install a new oil filter and fill the engine with the recommended amount and type of oil, as specified in the owner's manual.
How do I check the transmission fluid in my Mercedes CLK 55 AMG?
To check the transmission fluid level in your Mercedes CLK 55 AMG, ensure that the engine is warm and running. Locate the transmission dipstick, which is usually labeled and located near the back of the engine bay. Pull out the dipstick, wipe it clean, reinsert it fully, and then pull it out again. The fluid level should be between the minimum and maximum marks on the dipstick.
How do I diagnose a faulty alternator in my Mercedes CLK 55 AMG?
To diagnose a faulty alternator in your Mercedes CLK 55 AMG, you can perform a simple test using a multimeter. Start the engine and set the multimeter to DC voltage. Connect the positive (red) multimeter lead to the positive battery terminal and the negative (black) lead to the negative battery terminal. A healthy alternator should show a voltage reading between 13.5 to 14.5 volts. If the reading is significantly lower or fluctuating, it indicates a potential issue with the alternator, and further inspection or professional assistance may be required.
How do I replace a faulty ignition switch in my Mercedes CLK 55 AMG?
To replace a faulty ignition switch in your Mercedes CLK 55 AMG, start by removing any trim panels or covers necessary to access the switch. Disconnect the electrical connectors attached to the switch and remove any retaining screws or bolts. Install the new ignition switch in the reverse order, ensuring all electrical connections are properly secured. Test the functionality of the new ignition switch before reassembling any trim panels or covers.
How do I replace a faulty oxygen sensor in my Mercedes CLK 55 AMG?
To replace a faulty oxygen sensor in your Mercedes CLK 55 AMG, start by locating the sensor(s) on the exhaust system. Disconnect the electrical connector and use an oxygen sensor socket or wrench to remove the sensor. Install the new sensor, ensuring it is tightened to the proper torque specification. Reconnect the electrical connector and clear any stored fault codes using a diagnostic tool, if necessary.
How do I replace a headlight bulb in my Mercedes CLK 55 AMG?
To replace a headlight bulb in your Mercedes CLK 55 AMG, you need to access the back of the headlight assembly by opening the hood. Locate the bulb holder and twist it counterclockwise to remove it. Disconnect the electrical connector and remove the old bulb. Install the new bulb, reconnect the electrical connector, and secure the bulb holder back into place.
How do I replace the battery in my Mercedes CLK 55 AMG?
To replace the battery in your Mercedes CLK 55 AMG, first, ensure that the engine is off and the key is removed from the ignition. Locate the battery, usually located in the trunk or under the hood. Disconnect the negative (-) battery terminal first, followed by the positive (+) terminal. Remove any battery hold-down bracket and lift the old battery out. Install the new battery, reconnect the terminals in the reverse order, and secure the hold-down bracket.
How do I replace the serpentine belt in my Mercedes CLK 55 AMG?
To replace the serpentine belt in your Mercedes CLK 55 AMG, start by locating the belt routing diagram, usually found on a sticker in the engine bay. Use a wrench or tensioner tool to release the tension on the belt and remove it from the pulleys. Install the new belt following the correct routing as per the diagram. Finally, release the tensioner to apply proper tension to the new belt.
How do I reset the maintenance light in my Mercedes CLK 55 AMG?
To reset the maintenance light in your Mercedes CLK 55 AMG, turn the ignition to position 1 (do not start the engine). Within 4 seconds, press the trip odometer reset button twice quickly. Release the button and turn the ignition off. When you start the vehicle again, the maintenance light should be reset.
How do I troubleshoot a misfiring engine in my Mercedes CLK 55 AMG?
If you are experiencing a misfiring engine in your Mercedes CLK 55 AMG, start by checking the ignition system components, such as spark plugs, ignition coils, and ignition wires for any signs of damage or wear. Additionally, inspect the fuel system, including the fuel injectors and fuel pressure. If the issue persists, it is recommended to consult a professional mechanic or refer to the repair manual for further diagnosis and troubleshooting steps specific to your vehicle.
How often should I replace the air filter in my Mercedes CLK 55 AMG?
The air filter in your Mercedes CLK 55 AMG should be replaced approximately every 12,000 to 15,000 miles, or as specified in the owner's manual. However, if you frequently drive in dusty or dirty conditions, it is advisable to inspect and replace the air filter more frequently to ensure optimal engine performance and fuel efficiency.
What is the recommended tire pressure for my Mercedes CLK 55 AMG?
The recommended tire pressure for your Mercedes CLK 55 AMG can vary depending on the specific model year and tire size. It is best to refer to the tire information placard located on the driver's side door jamb or the owner's manual for the accurate recommended tire pressure. Maintaining the correct tire pressure is crucial for safety, tire longevity, and optimal handling.
What type of fuel should I use in my Mercedes CLK 55 AMG?
It is recommended to use premium unleaded gasoline with an octane rating of 91 or higher in your Mercedes CLK 55 AMG. Using a lower octane fuel may result in reduced performance and potential engine knocking. Refer to the owner's manual for specific fuel requirements and recommendations.
Mercedes CLK 55 AMG Manuals Index
Mercedes CLK 55 AMG Workshop Manual
- (Free)
Mercedes CLK 55 AMG Owners Manual
-
- Mercedes CLK 55 AMG 2002 Owners Manual Cabriolet
- (346 Pages)
- (Free)
-
- Mercedes CLK 55 AMG 2002 Owners Manual Coupe
- (330 Pages)
- (Free)
-
- Mercedes CLK 55 AMG 2003 Owners Manual
- (394 Pages)
- (Free)
-
- Mercedes CLK 55 AMG 2004 Owners Manual
- (464 Pages)
- (Free)
-
- Mercedes CLK 55 AMG 2005 Owners Manual Cabriolet
- (506 Pages)
- (Free)
-
- Mercedes CLK 55 AMG 2005 Owners Manual Coupe
- (498 Pages)
- (Free)
Mercedes CLK 55 AMG Misc Document
- (Free)
Related Models
