Opel Rekord Workshop Manuals and Repair Manuals

To adjust the headlights in your Opel Rekord, park the vehicle on a level surface facing a wall or garage door. Turn on the headlights and locate the adjustment screws, usually located on the headlight assembly or nearby. One screw controls the vertical adjustment, while the other controls the horizontal adjustment. Use a screwdriver or a suitable tool to turn the adjustment screws and align the headlights to the desired height and direction. Check the headlight alignment against the wall or garage door, making sure they are properly adjusted and not causing glare for oncoming drivers.

To check the transmission fluid level in your Opel Rekord, park the vehicle on a level surface, engage the parking brake, and allow the engine to idle. Locate the transmission dipstick, usually labeled with a yellow or red handle, and remove it. Wipe the dipstick clean, reinsert it fully, and then remove it again to check the fluid level. The fluid should be within the designated range on the dipstick. If it is low, add the recommended transmission fluid slowly and in small increments, checking the level frequently to avoid overfilling.

To jump-start your Opel Rekord, you will need a set of jumper cables and a running vehicle with a compatible battery. Park both vehicles close enough for the jumper cables to reach each battery. Connect one end of the red jumper cable to the positive (+) terminal of the dead battery, then connect the other end to the positive terminal of the charged battery. Connect one end of the black jumper cable to the negative (-) terminal of the charged battery, then attach the other end to a metal ground point on the dead vehicle, away from the battery. Start the engine of the charged vehicle, let it run for a few minutes, then try starting the dead vehicle. Once the dead vehicle starts, remove the jumper cables in the reverse order.

To replace a blown fuse in your Opel Rekord, first, locate the fuse box, which is usually located in the engine compartment or under the dashboard. Refer to the owner's manual or the fuse box cover for the specific fuse layout and ratings. Use a fuse puller or a pair of needle-nose pliers to remove the blown fuse and replace it with a new one of the same rating. Ensure the new fuse is securely seated and test the corresponding electrical component to confirm proper functionality.

To replace a headlight bulb in your Opel Rekord, open the hood and locate the back of the headlight assembly. Carefully disconnect the electrical connector from the bulb by gently pressing the release tab and pulling it away. Remove the retaining clip or ring that holds the bulb in place and carefully remove the old bulb. Insert the new bulb into the headlight assembly, ensuring it is securely seated. Reattach the retaining clip or ring, reconnect the electrical connector, and test the headlight to confirm proper operation.

To reset the maintenance reminder light in your Opel Rekord, turn the ignition key to the "ON" position without starting the engine. Within a few seconds, fully press and release the accelerator pedal three times. The maintenance reminder light should start flashing, indicating that it has been reset. If the light does not reset or continues to illuminate, consult the owner's manual or seek professional assistance.

The engine oil in your Opel Rekord should be changed approximately every 5,000 to 7,500 miles or every 6 to 12 months, depending on your driving conditions and the type of oil used. Regular oil changes are essential for maintaining the engine's performance and longevity, as they help remove dirt and contaminants, prevent engine wear, and ensure proper lubrication.

The air filter in your Opel Rekord should be replaced approximately every 15,000 to 30,000 miles or every 2 to 3 years, depending on driving conditions and the air quality in your area. A dirty or clogged air filter can restrict airflow to the engine, leading to decreased performance and fuel efficiency. Regularly inspect and replace the air filter as needed to ensure optimum engine performance.

The cabin air filter in your Opel Rekord should generally be replaced every 15,000 to 30,000 miles or every 2 to 3 years, depending on driving conditions and air quality. A clogged or dirty cabin air filter can impair the effectiveness of the vehicle's heating, ventilation, and air conditioning (HVAC) system, as well as negatively impact air quality inside the cabin. Regularly inspect and replace the cabin air filter to ensure clean and fresh airflow.

The spark plugs in your Opel Rekord should generally be replaced every 30,000 to 50,000 miles or every 3 to 5 years, depending on the type of spark plugs used and driving conditions. Worn or fouled spark plugs can cause misfires, reduced engine performance, and increased fuel consumption. Regularly inspect and replace the spark plugs as recommended by the manufacturer to ensure proper ignition and efficient combustion.

The timing belt in your Opel Rekord should generally be replaced every 60,000 to 100,000 miles or every 5 to 7 years, depending on the engine model and driving conditions. A worn or damaged timing belt can lead to catastrophic engine failure, so it is crucial to follow the manufacturer's recommended replacement interval. Regularly inspect the timing belt for signs of wear or damage and replace it as necessary to avoid potential engine damage.

The brake fluid in your Opel Rekord should generally be changed every 2 to 3 years, regardless of mileage. Over time, brake fluid absorbs moisture, which can lead to reduced braking performance and potential damage to the braking system. Follow the manufacturer's recommended interval and use the specified type of brake fluid to ensure optimal braking performance and safety.

The recommended tire pressure for your Opel Rekord can be found in the owner's manual or on a sticker located on the driver's side door jamb or inside the fuel filler door. It is important to maintain the proper tire pressure as specified by the manufacturer, as underinflated or overinflated tires can affect the vehicle's handling, fuel efficiency, and tire wear. Regularly check and adjust the tire pressure, preferably when the tires are cold, to ensure safe and optimal driving conditions.

It is recommended to use a high-quality, ethylene glycol-based coolant specifically formulated for your Opel Rekord. This type of coolant provides excellent protection against freezing and boiling, prevents corrosion and scale buildup, and helps maintain the engine's optimal operating temperature. Be sure to follow the manufacturer's instructions and mix the coolant with distilled water in the appropriate ratio for your climate.