Opel Vivaro Workshop Manuals and Repair Manuals

To change a flat tire on your Opel Vivaro, find a safe location to park the vehicle away from traffic. Use the jack and lug wrench provided in your vehicle's toolkit to raise the vehicle and remove the lug nuts. Take off the flat tire and replace it with the spare tire. Tighten the lug nuts in a star pattern, lower the vehicle, and fully tighten the lug nuts.

To change the oil in your Opel Vivaro, start by locating the oil drain plug underneath the engine. Use a wrench to remove the drain plug and let the old oil drain into a suitable container. Once the oil has fully drained, replace the drain plug and refill the engine with the recommended amount of new oil, making sure to use the correct oil type specified in your Opel Vivaro automotive repair manual.

To check the battery in your Opel Vivaro, turn off all electrical components and ensure the engine is off. Locate the battery under the hood, usually on one side of the engine compartment. Inspect the battery terminals for any corrosion or loose connections. Use a voltmeter or battery tester to check the battery voltage. If the voltage is below the recommended level, it may indicate a weak or discharged battery that needs to be charged or replaced.

To check the brake fluid level in your Opel Vivaro, locate the brake fluid reservoir under the hood. The reservoir is usually translucent, allowing you to see the fluid level without removing the cap. Ensure that the brake fluid level is between the minimum and maximum marks indicated on the reservoir. If the level is low, add the recommended brake fluid type as specified in your automotive repair manual.

To check the coolant level in your Opel Vivaro, let the engine cool down completely. Locate the coolant reservoir, usually a translucent plastic container, and check the level against the markings on the side. If the level is low, add a mixture of coolant and distilled water as specified in your automotive repair manual. It is important to never open the radiator cap when the engine is hot.

To check the transmission fluid level in your Opel Vivaro, start the engine and let it idle for a few minutes to warm up. Locate the transmission dipstick, usually labeled and located near the engine. Pull out the dipstick, wipe it clean, reinsert it fully, and then pull it out again. Check the fluid level against the markings on the dipstick. If the level is low, add the recommended transmission fluid as specified in your automotive repair manual.

To jump-start your Opel Vivaro, park another vehicle with a fully charged battery close to your vehicle. Connect one end of the positive (red) jumper cable to the positive terminal of the dead battery and the other end to the positive terminal of the charged battery. Connect one end of the negative (black) jumper cable to the negative terminal of the charged battery and the other end to a grounded metal surface on your vehicle, away from the battery. Start the engine of the vehicle with the charged battery and let it run for a few minutes before attempting to start your Opel Vivaro.

To replace a burnt-out headlight bulb in your Opel Vivaro, open the hood and locate the back of the headlight assembly. Twist off the bulb connector counterclockwise and carefully remove the old bulb. Insert the new bulb into the connector, making sure it is securely in place. Finally, twist the bulb connector clockwise to lock it into the headlight assembly.

To replace the cabin air filter in your Opel Vivaro, locate the filter housing, which is usually located behind the glove compartment or under the dashboard. Open the housing cover and remove the old filter. Insert the new filter, making sure it is correctly oriented and fits snugly. Close the housing cover and ensure it is securely fastened.

To replace the spark plugs in your Opel Vivaro, start by locating the spark plug wires or ignition coils. Carefully disconnect the wires or coils from the spark plugs. Use a spark plug socket and ratchet to remove the old spark plugs. Gap the new spark plugs according to the specifications in your automotive repair manual and install them using the socket and ratchet. Reconnect the spark plug wires or coils, ensuring they are securely in place.

To replace the windshield wipers on your Opel Vivaro, lift the wiper arm away from the windshield until it locks in an upright position. Locate the release tab on the wiper blade, press it, and slide the blade off the wiper arm. Align the new wiper blade with the arm and slide it into place until it clicks. Gently lower the wiper arm back onto the windshield.

To reset the service light in your Opel Vivaro, turn the ignition key to the "On" position without starting the engine. Press and hold the trip odometer reset button until the service light starts blinking. Release the button and turn off the ignition. When you start the engine again, the service light should be reset.

The air filter in your Opel Vivaro should be replaced according to the maintenance schedule outlined in your automotive repair manual. Typically, it is recommended to replace the air filter every 12,000 to 15,000 miles or once a year, depending on your driving conditions. A clogged or dirty air filter can restrict airflow to the engine, leading to decreased performance and fuel efficiency.

The recommended tire pressure for your Opel Vivaro can be found in your automotive repair manual or on a sticker located on the driver's side door jamb. It is important to maintain the correct tire pressure as specified by the manufacturer, as it affects your vehicle's handling, fuel efficiency, and tire wear. Use a tire pressure gauge to check the pressure regularly and adjust it accordingly.

The towing capacity of your Opel Vivaro depends on the specific model, engine, and optional equipment. Consult your automotive repair manual or contact the manufacturer for the exact towing capacity of your vehicle. It is important to never exceed the recommended towing capacity to ensure safe and efficient towing.