Volvo XC90 Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!

Volvo XC90
XC90 Information Not AvailableVolvo XC90 FAQ's
How do I change the cabin air filter in a Volvo XC90?
To change the cabin air filter in a Volvo XC90, locate the filter housing, which is usually located behind the glove compartment. Open the glove compartment and remove any contents or clips that may be blocking access to the filter housing. Once the housing is visible, release the clips or screws to open it and remove the old filter. Install a new cabin air filter, ensuring it is properly aligned, and close the housing. Finally, reassemble the glove compartment and test the HVAC system to ensure proper airflow.
How do I change the oil in a Volvo XC90?
To change the oil in a Volvo XC90, start by locating the oil drain plug underneath the vehicle. Use a wrench to loosen and remove the plug, allowing the oil to drain into a suitable container. Once the oil has completely drained, replace the drain plug and proceed to remove the oil filter. Install a new oil filter, ensuring it is properly secured, and then refill the engine with the recommended type and amount of oil.
How do I check and top up the coolant in a Volvo XC90?
To check and top up the coolant in a Volvo XC90, start by allowing the engine to cool down completely. Locate the coolant reservoir, typically located near the radiator. The reservoir will have markings indicating minimum and maximum levels. Check the coolant level and add a mixture of coolant and distilled water if necessary, ensuring it does not exceed the maximum level. It is important to use the correct coolant type as specified in the vehicle's manual.
How do I check the brake fluid level in a Volvo XC90?
To check the brake fluid level in a Volvo XC90, start by locating the brake fluid reservoir, typically located on the driver's side of the engine compartment. Wipe the reservoir cap clean to prevent any contamination from entering the system. Remove the cap and visually check the fluid level, which should be between the "Min" and "Max" markings on the reservoir. If needed, add the recommended brake fluid to bring the level within the specified range. Take care not to spill any brake fluid, as it can damage painted surfaces.
How do I check the transmission fluid level in a Volvo XC90?
To check the transmission fluid level in a Volvo XC90, start by parking the vehicle on a level surface and allowing the engine to idle. Locate the transmission dipstick, which is usually labeled and located near the back of the engine bay. Remove the dipstick, wipe it clean, and reinsert it fully into the transmission. Remove the dipstick again and check the fluid level, which should fall within the "Full" and "Add" marks on the dipstick. If needed, add the recommended transmission fluid through the dipstick tube, taking care not to overfill.
How do I replace a fuse in a Volvo XC90?
To replace a fuse in a Volvo XC90, start by locating the fuse box, which is usually found in the engine compartment or under the dashboard. Open the fuse box cover and locate the fuse that needs to be replaced, referring to the diagram on the inside of the cover for identification. Use a fuse puller or pliers to remove the faulty fuse from its socket. Install a new fuse of the same rating and push it firmly into the socket until it is secure. Finally, close the fuse box cover and test the corresponding electrical component to ensure proper functionality.
How do I replace a headlight bulb in a Volvo XC90?
To replace a headlight bulb in a Volvo XC90, start by opening the hood and locating the rear of the headlight assembly. Remove the rubber cover to access the bulb housing. Unclip the bulb connector and carefully remove the old bulb. Install a new bulb, making sure it is securely seated, and reconnect the bulb connector. Finally, replace the rubber cover, close the hood, and test the headlight to ensure it is functioning properly.
How do I replace the battery in a Volvo XC90?
To replace the battery in a Volvo XC90, start by turning off the ignition and ensuring all electrical devices are turned off. Locate the battery, typically located in the engine compartment. Remove the negative (-) terminal first, followed by the positive (+) terminal. Remove any brackets or fasteners securing the battery in place and carefully lift it out of the battery tray. Install the new battery, making sure the positive and negative terminals are correctly connected, and secure it with any brackets or fasteners. Finally, reconnect the positive (+) terminal first, followed by the negative (-) terminal.
How do I replace the brake pads on a Volvo XC90?
To replace the brake pads on a Volvo XC90, start by safely lifting the vehicle and removing the wheels. Locate the brake caliper, usually secured with bolts, and remove them to access the brake pads. Remove the old brake pads from the caliper bracket and install the new pads, ensuring they are properly aligned and securely in place. Reattach the brake caliper, tighten the bolts to the recommended torque, and repeat the process for the remaining wheels. Finally, lower the vehicle and test the brakes to ensure proper operation.
How do I replace the fuel filter on a Volvo XC90?
To replace the fuel filter on a Volvo XC90, start by relieving the pressure in the fuel system by disconnecting the fuel pump fuse or relay and allowing the engine to idle until it stalls. Locate the fuel filter, usually along the fuel line under the vehicle. Use appropriate tools to remove the fittings or clamps securing the fuel lines to the filter. Disconnect the fuel lines from the filter and remove the old filter from its mounting bracket. Install the new fuel filter, reconnect the fuel lines, and secure them with fittings or clamps. Finally, reinstall the fuel pump fuse or relay and start the engine to check for any leaks.
How do I replace the serpentine belt on a Volvo XC90?
To replace the serpentine belt on a Volvo XC90, start by locating the belt tensioner, which is usually a spring-loaded pulley. Use a wrench or socket to rotate the tensioner in the direction indicated on the belt routing diagram, relieving tension on the belt. Slide the old belt off the pulleys, making note of the belt's routing for installation of the new belt. Install the new belt onto the pulleys, following the belt routing diagram. Finally, release the tensioner, ensuring the belt is properly seated on all pulleys, and visually inspect the belt for correct alignment and tension.
How do I replace the spark plugs in a Volvo XC90?
To replace the spark plugs in a Volvo XC90, start by identifying the spark plug wires or ignition coils, depending on the engine type. Disconnect the wires or coils from the spark plugs and remove any covers or components blocking access to the plugs. Use an appropriate spark plug
How do I replace the windshield wipers on a Volvo XC90?
To replace the windshield wipers on a Volvo XC90, start by lifting the wiper arm away from the windshield and locating the release tab or button on the wiper blade. Press or slide the tab/button to release the old wiper blade from the wiper arm. Attach the new wiper blade by sliding it onto the wiper arm until it clicks into place. Lower the wiper arm back onto the windshield and test the new wipers to ensure proper operation.
How do I reset the service light on a Volvo XC90?
To reset the service light on a Volvo XC90, start by turning the ignition switch to the "ON" position without starting the engine. Press and hold the trip odometer reset button located on the instrument cluster. While holding the button, turn the ignition switch to the "OFF" position, and then back to the "ON" position. Continue holding the reset button until the service light flashes and resets, indicating that the reset procedure is complete.
What is the recommended tire pressure for a Volvo XC90?
The recommended tire pressure for a Volvo XC90 can vary depending on factors such as load and driving conditions. However, as a general guideline, the recommended tire pressure for the XC90 is typically around 35 PSI (pounds per square inch) for all four tires. It is important to regularly check and adjust the tire pressure to ensure optimal performance, safety, and fuel efficiency.
Get notified for new manuals?
We'll send you a quick email when a new Volvo XC90 manual is added.
Volvo XC90 Owners Manual

-
- Volvo XC90 2004 Owners Manual
- (245 Pages)
- (Free)
-
- Volvo XC90 2009 Owners Manual
- (290 Pages)
- (Free)
-
- Volvo XC90 2016 Owners Manual
- (570 Pages)
- (Free)
Volvo XC90 Misc Document

- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
- (Free)
Related Models
